Local Services

Rv Repair Shop Orange County CA

Orange County Rv Roof Leak Repair

Published May 04, 25

11 min read

Table of Contents

– Rv Trailer Roof Repair Orange County, CA
– OCRV Center
– Repair Rv Roof Leak Orange County, CA
– Rv Roof Repair Service Near Me Orange County, CA
– Rubber Roof Installation Orange County, CA
– Rv Roof Repair Near Me Orange County, CA
– Repair Rv Roof Orange County, CA
– Best Rv Roof Repair Orange County, CA
– Rv Roof Replacement Orange County, CA
– Rv Rubber Roof Replacement Orange County, CA
– Rv Rubber Roof Repair Orange County, CA
– Rv Roof Maintenance Orange County, CA
– Rv Roof Leak Repair Orange County, CA
– Rv Roof Replacement Orange County, CA
– Rv Fiberglass Roof Repair Orange County, CA
– OCRV Center

Rv Trailer Roof Repair Orange County, CA

OCRV Center

23281 La Palma Ave Yorba Linda, CA 92887
(714) 909-1444
OCRV Center

For fiberglass roofings, preliminary sanding is advised to make certain the finish sticks properly.: Treating times differ with temperature and moisture. If the finish starts to skin over in the container, eliminate this layer and mix well prior to continuing. For application, conventional paint rollers are suitableapply with a light touch, however don't be timid with the amount of covering you roll on.

We stand by the high quality of our item with a 100% Life time Guarantee, providing you with full self-confidence in your purchase. That's how very easy it is to fix your RV's roofing system and ignore doing roofing upkeep ever again. Go ahead and recover your roofing for the last time now.

Acetone and dustcloths for a last clean (available at shops like Home Depot or Walmart). Single usage paint brushes, rollers, and post extensions (can be located in a Buck Shop). Repaint tray and small pail Disposable gloves Painter's tape.

Membrane must be mounted onto clean wooden surface area, do not install on top of existing membrane, glue, and so on. Router all air vent and accessory openings. Get rid of all particles off roof covering with air pipe.

Repair Rv Roof Leak Orange County, CA

That is, fold it in fifty percent so half of the roofing is revealed. Apply adhesive in a damp film density of 8-10 mils with a short-napped paint roller to the subjected fifty percent of the roofing decking, brush can be utilized yet is extra difficult.

Rubber Roof Installation Orange County, CA

Remove all air pockets and wrinkles with a squeegee (grey neoprene head will not streak) or linoleum roller; press strongly working from the center exterior toward the edges, do not be on the roof covering during this moment. All wrinkles should be eliminated at this moment for a high quality setup.

Alternate technique, staple membrane layer in position using" staples 3"-5" apart after that apply bar. If roof-edge moldings are not installed on roof covering during this time around membrane will certainly peel-up as drying. 8. Apply putty/butyl tape to the backside of the front and rear termination moldings/caps. Front cap will certainly lay on top of the membrane, membrane layer needs to lay on top of the rear cap.

Rv Roof Repair Service Near Me Orange County, CA

Both sides of the front and rear roofing system molding have to be sealed with caulk/sealant. A minimal 3/8" bead will certainly function for a lot of applications. Openings & Vents and Home Appliance Installation1. Utilizing an utility blade "x" reduced all roof covering openings. Make certain you round all 90-degree corners to remove the opportunity of running cuts.

To achieve best bond, apply to both substrates with 5-6 mil coat weight and permit to dry, after that laminate to membrane and use pressure with roller to insure 100% get in touch with. Diluent Water, if required. Use as obtained. Clean-up needs only cozy water. Shop product in a cool, completely dry location. Item should not be kept in direct sunshine.

Eye get in touch with If item get in touches with eye, flush with water for at least 15 mins and seek clinical focus quickly. Skin get in touch with If product calls skin, wash impacted location with soap and water.

Rubber Roof Installation Orange County, CA

Mask both sides of joint with covering up tape. Cut nozzle to desired grain size. Pierce seal. Lots sealant cartridge in caulking gun. Place nozzle into joint and apply sealer into gap. Use over 40 deg F (5 deg C)Smooth or "device" grain if needed. Eliminate covering up tape promptly. Clean hands and tools thoroughly before cleaning with soap and water.

PRECAUTIONNot for internal usage. Direct contact of uncured sealer irritates eyes and might irritate skin. In case of eye get in touch with flush eyes with water for 15 minutes and call a doctor. In instance of skin get in touch with, completely clean skin with soap and water. In case of intake look for medical attention instantly.

Rv Roof Repair Near Me Orange County, CA

My Motor home roof that requires to be replaced! If you're like me and have even more time than cash, then probably your best option is to purchase an old Recreational vehicle and fix it up.

I obtain it. I bought my Motor home over a year earlier and really did not have the intestines to start tackling this task till today. I acquired this 1993 Jamboree for $5000.

Repair Rv Roof Orange County, CA

The catch? Water damage! I've never functioned on a recreational vehicle before and I need to admit, I'm scared. I've done a great deal of house renovation and I'm still terrified. That's since this is all new to me and I have no concept what to anticipate. Ideally if you're thinking about doing this on your own, following along on my recreational vehicle roofing system substitute task will provide you the nerve to dive in! The devices I utilized today.

I acquired a 12 x 26 SuperMax Canopy by ShelterLogic (over $450 on Amazon but I acquired mine from North Tool for about $340!) and raised the legs with wood extensions to make the canopy high enough that I might depend on the roof and stroll underneath it. That seemed to be my least expensive choice.

I figured I prefer to have it semi-portable so I went with the canopy, plus this enables me to readjust the height backwards and forwards when I need to. Orange County Rv Roof Leak Repair. Of training course the most affordable option of all would be to simply throw an excellent tarpaulin over the top of your motor home for rainy days and just work with warm days! Originally I raised the legs with 1 1/2 PVC pipeline that fit inside the legs and after that I affixed a hose pipe clamp around the PVC pipe to stand up the canopy legs

Best Rv Roof Repair Orange County, CA

I sawed 1 1/4 square legs from 24's to place inside the canopy legs (once again holding the cover up with pipeline clamps.) and strengthening the four edges with an additional 24 screwed to it. This is still a little drooping. I possibly must have forked out for some rigid steel pipeline from the beginning.

Cracks in the EPDM roof at edge of camper. An old patch job on the recreational vehicle rubber roofing. Tons of caulk loaded over old trouble areas. As you can see, this roofing system has had a lot of problems for many years. Looking from the within the camper there have plainly been leakages in lots of areas of the roofing.

On the base is the original EPDM rubber roofing layer. I understand it's EPDM rubber and not TPO rubber because of the black support. On top of my EPDM roofing is a slim Recreational vehicle roofing system finish that was applied later.

Rv Roof Replacement Orange County, CA

I just left the roofing system finishing adhered to the EPDM roof covering and drew them up together. (You don't need to peel them up separately.) Beginning to peel roofing coating. Peeling off up section of the lower layer of rubber. This shows that the original motor home roofing system was EPDM as a result of the black support.

All rubber roofing removed from camper. There was a sticky under the lower layer of rubber that was still pretty well stuck in numerous areas, yet with an excellent little bit of force it peeled up cleanly.

Rv Rubber Roof Replacement Orange County, CA

Currently I might see all the damaged plywood roof decking beneath. I chose to peel off the rubber before removing fixtures simply so I can see what I was dealing with.

If you believe you'll be saving the roof covering outdoor decking plywood (not changing it), then you could save on your own some cleanup trouble by removing the fixtures initially and after that peeling off up the rubber! Extra water harmed areas on Motor home roof decking.

I went for the simplest one first, a vent cap from a cooking area sink plumbing vent pipe. Starting to scrape caulk and sealer. I utilized a stiff scrape with a chisel-like blade and simply began prying and breaking and scuffing and hacking. There is nothing else means around this, you just have to start digging until you subject the screw heads.

Loosening the screws in air vent cap. The screws on this air vent cap were hex-head metal screws so I used a little outlet chauffeur to eliminate them. Some appeared tidy. Others were rusted and I had to utilize a vice-grip pliers to get hold of the heads and turn them gradually.

Rv Rubber Roof Repair Orange County, CA

I discovered an old wasp nest inside the air vent cover. This is a view I'll possibly need to obtain used to, finding the remains of pet habitation high and low. I spend a horrible great deal of my time creating excellent wild animals environment in my lawn so I don't obtain annoyed when a creature chooses to set up home in my motor home.

Fortunately nobody was home in this old nest so I just tossed it. Perhaps I'll put a screen over it when replacing it. Which brings us to the next factor. You should try not to harm these items (like vent covers and caps) as you're removing the old caulk and sealer just in instance you require to utilize them again.

My roof covering air vent likewise had a vent cover over it. Beginning on the roofing system air vent. Hardware exposed on roofing vent cap, the initial nut came off tidy.

Rv Roof Maintenance Orange County, CA

Bolt is rotating. The bolts on this recreational vehicle roof vent cover were nuts on tiny screws. The first one came off great with an extension socket set. The 2nd one just began rotating, implying the screw was not repaired in place however turning in addition to the nut. Downer. A peek at the equipment holding down the roofing vent cover.

I didn't have any type of excellent way to hold the screw in place so rather I opted to saw through the bolts with a reciprocating saw. Sawing via screws on roofing vent cover - Orange County Rv Roof Leak Repair. I made use of a cordless reciprocating saw with a metal-cutting blade but it was difficult to obtain the blade flat adequate to get to the screws so close to the roofing system deck

Flexing the blade a little bit to get to close to the roof deck. Cover removed from roofing system vent.

Most were so old and rusted that they sheared off when I loosened after that with a great deal of pressure. Loosening the braces that held the vent cover in position. Then I scratched a lot more caulk and roof covering sealant off the flange of the roof covering vent itself. I soon found there disappeared screws or hardware stifling so I surrendered on the scraping and went inside the motor home After scratching the caulk and sealant from flange of roofing system air vent, no more screws! Unscrewing the inside cover plate of roofing system air vent follower in recreational vehicle restroom.

Rv Roof Leak Repair Orange County, CA

I picked a drill little bit close to the dimension of the shaft of the screws that I had actually already drawn out and started boring. Choosing a drill little bit for drilling out a screw head.

Security glasses suggested. I pierced out the heads, one stood out off and the various other I was getting frustrated with and provided it a tug prior to it was pierced through. Rather than popping off the screw head, the plastic just dissolved around the hot screw head. Whoops. Hope I do not have to recycle this cover.

Raising off the old roofing system vent. There are 2 cables running to the roof covering vent (a black hot cord and a white neutral cable) that you'll require to clip to eliminate the old air vent.

Rv Roof Replacement Orange County, CA

These are the cords linking the roof covering airing vent follower. Roofing vent removed and cleaned up. After clipping the cord and eliminating the air vent, I cleaned up any kind of continuing to be goop and obtained my very first excellent look at the roof framework.

Some RV roofings are framed with wood, others have metal framing. I had no idea what remained in my camper until this factor. Not too pleased about the amount of corrosion on it, but with any luck it is still structurally seem! I removed some corrosion and made a big mess inside the shower room.

Oops. Perhaps I need to have placed a tarpaulin down initially. My last goal of the day was to get the refrigerator vent cover off. I noticed RV sealant blobs at 4 points on the cover so assumed there have to be screws under them. I tore them up and discovered Phillips screw heads.

Rv Fiberglass Roof Repair Orange County, CA

OCRV Center

Address: 23281 La Palma Ave Yorba Linda, CA 92887
Phone: (714) 909-1444
OCRV Center

Exposing the screws in the fridge air vent cap. Peeling off old RV roofing covering in addition to fridge vent cap I also discovered that there was a layer of recreational vehicle roof covering finishing over the vent cap. These finishings are painted on with a brush so plainly whoever did this covering just blobbed know top of whatever.

Share us on...

Table of Contents

– Rv Trailer Roof Repair Orange County, CA
– OCRV Center
– Repair Rv Roof Leak Orange County, CA
– Rv Roof Repair Service Near Me Orange County, CA
– Rubber Roof Installation Orange County, CA
– Rv Roof Repair Near Me Orange County, CA
– Repair Rv Roof Orange County, CA
– Best Rv Roof Repair Orange County, CA
– Rv Roof Replacement Orange County, CA
– Rv Rubber Roof Replacement Orange County, CA
– Rv Rubber Roof Repair Orange County, CA
– Rv Roof Maintenance Orange County, CA
– Rv Roof Leak Repair Orange County, CA
– Rv Roof Replacement Orange County, CA
– Rv Fiberglass Roof Repair Orange County, CA
– OCRV Center

Local Services

Navigation

Home